Coleman Single Piece Air Handlers F*FP Manuel d'utilisateur télécharger pdf

292043-UIM-B-0707

SINGLE PIECE

AIR HANDLERS

MODELS: F*FP

INSTALLATION MANUAL

ISO 9001

Certified Quality

Management System

SAFETY

This is a safety alert symbol. When you see this symbol on

labels or in manuals, be alert to the potential for personal

injury.

Understand and pay particular attention to the signal words DANGER,

WARNING, or CAUTION.

DANGER indicates an imminently hazardous situation, which, if not

avoided, will result in death or serious injury

WARNING indicates a potentially hazardous situation, which, if not

avoided, could result in death or serious injury

CAUTION indicates a potentially hazardous situation, which, if not

avoided may result in minor or moderate injury.

It is also used to

alert against unsafe practices and hazards involving only property dam-

age.

Improper installation may create a condition where the operation of

the product could cause personal injury or property damage.

Improper installation, adjustment, alteration, service or mainte-

nance can cause injury or property damage. Refer to this manual

for assistance or for additional information, consult a qualified con-

tractor, installer or service agency.

This product must be installed in strict compliance with the installa-

tion instructions and any applicable local, state, and national codes

including, but not limited to building, electrical, and mechanical

codes.

TABLE OF CONTENTS

SAFETY . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

SPECIFIC SAFETY RULES AND PRECAUTIONS . . . . . . . . . . . . . . . 2

SAFETY REQUIREMENTS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

GENERAL INFORMATION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

INSPECTION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

LIMITATIONS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

CLEARANCES . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

LOCATION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

HORIZONTAL DRAIN PAN CONVERSION . . . . . . . . . . . . . . . . . . . . 3

DUCT CONNECTIONS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5

AIR FILTERS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5

SUSPENSION KITS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5

COIL METERING DEVICES . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .5

REFRIGERANT LINE CONNECTION . . . . . . . . . . . . . . . . . . . . . . . . .6

ELECTRIC HEATERS & OPERATING CONTROLS . . . . . . . . . . . . . .6

LOW VOLTAGE CONTROL CONNECTION . . . . . . . . . . . . . . . . . . . .8

LINE POWER CONNECTIONS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .8

BLOWER SPEED CONNECTIONS . . . . . . . . . . . . . . . . . . . . . . . . . . .8

DRAIN CONNECTIONS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .16

MAINTENANCE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .16

COIL CLEANING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .16

LUBRICATION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .16

CONDENSATE DRAINS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .16

LIST OF FIGURES

Plenum Clearances . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3

Typical Installation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3

Filter Access & Drain Pan Conversion / Coil Baffle . . . . . . . . . . . . . . . 4

Dimensions & Duct Sizes . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4

Typical Horizontal Installation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5

TXV Bulb Installation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5

Bulb Location . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6

Control Board . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .6

Electric Heaters in Horizontal Configuration - Right Hand Air Flow . . .6

Line Power Connections . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .7

Blower Speed Connections . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .7

Cooling Models with Electric Heat Wiring . . . . . . . . . . . . . . . . . . . . . .14

Single Stage Heat Pump Control Wiring . . . . . . . . . . . . . . . . . . . . . . .14

LIST OF TABLES

Dimensions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4

Installed TXV Sizes . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5

Physical and Electrical Data . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9

Electrical Data - Cooling Only (50 & 60 Hz) . . . . . . . . . . . . . . . . . . . . . 9

Conversion Table . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9

Electrical Data - 1 Ø - 208/230-1-60 . . . . . . . . . . . . . . . . . . . . . . . . . 10

Electrical Data - (For Single Source Power Supply) -

Copper Wire 1 Ø - 208/230-1-60 . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11

Electrical Data - (For Multi-Source Power Supply) -

Copper Wire 1 Ø - 208/230-1-601 . . . . . . . . . . . . . . . . . . . . . . . . . . .11

Electrical Data - 3 Ø - 208/230-3-60 . . . . . . . . . . . . . . . . . . . . . . . . . .12

Electrical Data - (For Single Source Power Supply) -

Copper Wire 3 Ø - 208/230-3-60 . . . . . . . . . . . . . . . . . . . . . . . . . . . .12

Airflow Data for 230 Volt - Heat Pump Models . . . . . . . . . . . . . . . . . .13

Airflow Data for 208 Volt - Heat Pump Models . . . . . . . . . . . . . . . . . .14

1 2 3 4 5 6 ... 15 16

Résumé du contenu

Page 1 - INSTALLATION MANUAL

292043-UIM-B-0707SINGLE PIECE AIR HANDLERSMODELS: F*FPINSTALLATION MANUALISO 9001Certified QualityManagement SystemSAFETYThis is a safety alert symbol

Page 2 - 2 Unitary Products Group

292043-UIM-B-070710 Unitary Products Group* May be 0 (no breaker) or 1 (with breaker).TABLE 6: Electrical Data - 1 Ø - 208/230-1-601Models F*FPHeater*

Page 3 - Unitary Products Group 3

292043-UIM-B-0707Unitary Products Group 11* May be 0 (no breaker) or 1 (with breaker).TABLE 7: Electrical Data - (For Single Source Power Supply) - Co

Page 4 - 4 Unitary Products Group

292043-UIM-B-070712 Unitary Products GroupTABLE 9: Electrical Data - 3 Ø - 208/230-3-601Models F*FPHeater2ModelMax. Static& Min. CFMTotal HeatKW S

Page 5 - COIL METERING DEVICES

292043-UIM-B-0707Unitary Products Group 13All F*FP series air handler units are UL Listed up to 0.50" w.c. external static pressure, including ai

Page 6 - REFRIGERANT LINE CONNECTION

292043-UIM-B-070714 Unitary Products GroupTABLE 12: Airflow Data1 for 208 Volt - Heat Pump Models1. Includes Return Air Filter and Largest Electric He

Page 7 - Unitary Products Group 7

292043-UIM-B-0707Unitary Products Group 15NOTES:1. “Y” Terminal on Air Handler Control Board must be connected for full CFM and applications requiring

Page 8 - BLOWER SPEED CONNECTIONS

Page 9 - Unitary Products Group 9

292043-UIM-B-07072 Unitary Products GroupSPECIFIC SAFETY RULES AND PRECAUTIONS1. Install this air handler only in a location and position as specified

Page 10 - 10 Unitary Products Group

292043-UIM-B-0707Unitary Products Group 36. When an evaporator coil is installed in an attic or above a finishedceiling, an auxiliary drain pan should

Page 11 - Unitary Products Group 11

292043-UIM-B-07074 Unitary Products Group FIGURE 3: Filter Access & Drain Pan Conversion / Coil BaffleFILTER4B - SIDE VIEW"S" BRACKET M

Page 12 - 12 Unitary Products Group

292043-UIM-B-0707Unitary Products Group 5DUCT CONNECTIONSNOTE: The electric heat accessory should be installed before the sup-ply air duct is attached

Page 13 - Unitary Products Group 13

292043-UIM-B-07076 Unitary Products Group• If the suction line is 3/4" diameter - position the bulb near the topof the copper tube as shown. If t

Page 14 - 14 Unitary Products Group

292043-UIM-B-0707Unitary Products Group 7

Page 15 - Unitary Products Group 15

292043-UIM-B-07078 Unitary Products GroupLOW VOLTAGE CONTROL CONNECTIONThe 24 volt power supply is provided by an internally wired low voltagetransfor

Page 16 - Unitary 5005 Norman

292043-UIM-B-0707Unitary Products Group 9TABLE 3: Physical and Electrical DataModels F*FP 024 030 036 040Blower - Diameter x Width 10 x 6 10 x 8 10 x